Kia ProCeed Problems Common Issues and Repair Costs
Car Problems 

Kia ProCeed Problems: Common Issues and Repair Costs

@CarExamer 5 Views 0 Comments

The Kia ProCeed is a stylish estate car with sporty looks and solid everyday usability. But like any modern car, it comes with a few known faults that potential buyers should watch out for. Whether you already own one or you’re thinking about buying used, this guide covers the most common Kia ProCeed problems and what they typically cost to repair in the UK.

Book inspection

1. Clutch and Gearbox Problems – £400 to £1,900

Common in: Manual 1.4 T-GDi and 1.6 CRDi models (2019 to 2022)

Several UK owners have reported early clutch wear and gear shifting problems, especially around town or during stop-start driving.

What to look out for:

  • Juddering when setting off
  • Slipping clutch under load
  • Crunching into gear or hard gear changes

Repair costs:

  • Clutch kit: £400 to £600
  • Dual-mass flywheel (if required): £400 to £600 extra
  • Reconditioned gearbox or major repair: £1,400 to £1,900

If the clutch bite is high or the gearshift is not smooth, it’s likely that clutch components or gearbox parts are worn.

2. Engine and Turbo Issues – £300 to £2,100

Seen in: 1.4 and 1.6 T-GDi petrol, and 1.6 CRDi diesel engines

The engines in the ProCeed are generally reliable, but there are known issues with turbo performance and minor oil leaks.

Typical problems include:

  • Loss of power or poor throttle response
  • Warning light linked to turbo or EGR system
  • Light oil leaks near the valve cover or turbo housing

Likely repairs and costs:

  • Turbo actuator or boost sensor: £300 to £500
  • Full turbo replacement: £1,300 to £2,100
  • EGR valve clean or replacement: £250 to £400
  • Oil seal or gasket repair: £100 to £300

If the engine feels flat or hesitates during acceleration, it may be a sensor or turbo fault starting to develop.

3. Electrical and Infotainment Faults – £80 to £750

Reported in: 2020 onwards, especially in GT-Line and GT trims

Modern ProCeeds are packed with tech, but a few owners have experienced bugs with digital displays and cameras.

Issues reported:

  • Sat nav freezing
  • Rear camera delay
  • Digital dash flickering or going black

Fixes and costs:

  • Software update or reset: £80 to £150
  • New reverse camera: £300 to £400
  • Digital instrument cluster: £500 to £750
  • Sensor recalibration: £100 to £200

These faults are usually annoying more than dangerous, but they’re not cheap once the car is out of warranty.

4. Suspension Wear and Noise – £200 to £850

Appears after: 40,000 miles and more

The ProCeed rides firmer than most family cars, so worn suspension parts show up sooner, especially on rough UK roads.

Watch for:

  • Knocking sound from the front
  • Tyres wearing unevenly
  • Vibration through the steering wheel

Repair costs:

  • Anti-roll bar links: £200 to £300
  • Top mounts or bearings: £250 to £350
  • Shock absorbers (front pair): £600 to £850
  • Four-wheel alignment: £100

If the front end sounds noisy over bumps, suspension wear is likely the cause.

5. Air Conditioning and Heating Problems – £100 to £650

Reported in: 2019 to 2022 models

Some owners have found the cabin air system to be inconsistent, either not cooling or failing to heat properly in cold weather.

Typical problems:

  • AC blows warm air only
  • Fan speed not adjusting
  • Heater stuck on cold

Repair costs:

  • AC re-gas: £100 to £150
  • Temperature sensor: £150 to £250
  • Control unit or dashboard panel: £300 to £500
  • Compressor (rare cases): £500 to £650

A weak air con system could be low on gas, but if it doesn’t work after a re-gas, it may be a sensor or panel issue.

Kia ProCeed Common Problems and Costs Summary

Problem AreaAffected ModelsUK Repair Cost Estimate
Clutch and gearbox2019–2022£400 – £1,900
Turbo and engine faults2019–2023£300 – £2,100
Electrical issues2020 onwards£80 – £750
Suspension problemsAll models£200 – £850
Air conditioning faults2019–2022£100 – £650

Is the Kia ProCeed Still a Good Buy?

Yes. The Kia ProCeed remains one of the best-looking and best-value estate cars on the market. Its long warranty and solid engines make it a strong choice — if you go in knowing what to check for.

What’s good:

  • Stylish design with lots of space
  • Strong engines and good efficiency
  • 7-year manufacturer warranty
  • Comfortable for long drives

Things to check before buying:

  • Clutch wear and gear change feel
  • Any engine hesitation or warning lights
  • Suspension noises or poor ride quality
  • Functioning infotainment and air con

Don’t Buy Without a Full Inspection

Test drives don’t always reveal hidden issues, and even main dealer history can miss early wear.

Best move: Book a CAREXAMER vehicle inspection. Their detailed reports cover all key systems and go deeper than standard AA or RAC checks.

Final Word

The Kia ProCeed is a great car with a strong balance of design, reliability, and practicality. Most problems are manageable and well known. With the right checks before you buy, you can avoid costly surprises and enjoy the drive.

Buying a used VW. Buying used vauxhall, BMW, Jaguar, Ford, Volvo, Range rover, Bentley, Aston Martin, Porsche, Ferrari, Lamborghini, Maserati, Hyundai, Tesla, Honda, Pagani

Leave a Reply